TM 55-8145-202-14
CHAPTER 3
OPERATOR MAINTENANCE INSTRUCTIONS
Paragraph
Page
Operator Lubrication Instructions ........................................................................................... 3-1
Operator Troubleshooting Instructions .................................................................................. 3-1
Introduction................................................................................................................................. 3-1
Malfunction Index ....................................................................................................................... 3-1
Troubleshooting Table ................................................................................................................ 3-2
Operator Maintenance Procedures......................................................................................... 3-3
Section I. OPERATOR LUBRICATION INSTRUCTIONS
a.
There are no operator lubrication requirements for the refrigerated container.
b.
Refer to TM 9-4110-258-13 for lubrication requirements on the refrigeration unit.
c.
Refer to TM 5-6115-585-12/34 for lubrication requirements on the generator set.
Section II. OPERATOR TROUBLESHOOTING INSTRUCTIONS
3-1.
INTRODUCTION.
a.
The troubleshooting table lists the common malfunctions which you may find during operation of the
refrigerated container. You should perform the tests, inspections and corrective actions in the order they
appear in the table.
b.
This table cannot list all the malfunctions that may occur, all the tests or inspections needed to find fault, or
all the corrective actions needed to correct the fault. If the equipment malfunction is not listed or actions
listed do not correct the fault, notify your supervisor.
c.
Refer to TM 9-4110-258-13 for troubleshooting malfunctions on the refrigeration unit.
d.
Refer to TM 5-6115-585-12/34 for troubleshooting malfunctions on the generator set.
3-2.
MALFUNCTION INDEX.
Malfunction
Page
1
Rear Doors Will Not Close
2
Water Will Not Drain from Container Floor
3
Temperature Recorder Does Not Record or Does Not Record Properly
4
Temperature Inside Container Will Not Stabilize
5
Generator Set Not Working Properly
3-1
